Peninsula Excavating | exploRVistas

Leelanau County, Michigan – Saturday, May 29 – Written by Jim

Our cabin has begun rising from the foundation!

Well, not quite like that, but we do have progress to report! Our framers showed up this week and went at it in earnest. Prior to their arrival, I took the opportunity to insulate the lower four feet of the crawl space.

Getting this much done while standing straight up made life a lot easier. The insulation is two pieces of 1-1/2” thick polyiso board. Putting it up was a fairly simple process:

*Drill a hole with a 5” long maso*nry *bit.*

*Tap it with a* *rubber mallet until it is tight.*

The top part of the insulation will be finished once the floor joists are mounted to the top of the crawl space wall. I will also use aluminum tape to seal the joints in the foam board. Time for me to stand back and watch the framers build!

Ryan, Paul and Richard dove right into it. First thing they did was to assemble the center beam and support it with posts. Then came the treated wood sill plate on top of the foundation walls, along with a foam strip of sill sealer between them. The sill plate is attached to the block wall below with anchor bolts that the mason set into concrete. Follow that with the I-joists that span the entire width of the cabin and the rim joist around the outside.

It was then time for me to get back in the action. With us getting our material weeks earlier, I stored all of that high-priced OSB flooring in the barn. We purchased pallet forks for the front of our tractor last year and I was able to bring out several sheets at a time. They mentioned how it really helped them speed things up. Speaking of high priced lumber: This time last year, a sheet of 3/4” subfloor like this was in the $17 range. We purchased it in March at Menard’s for less that $30 a sheet. We thought that was crazy. Well, it is a good thing we bought it when we did, as we had to purchase two additional sheets to finish the floor. The price? A whopping $72 a sheet!

The crawl space is getting dark down there. Other than whatever comes through the hatch in the center of the cabin, that space hopefully won’t see daylight for a long time! By noon the next day, the floor was complete.

As the framers started building the walls, Adam from Peninsula Excavating started backfilling. He worked all afternoon and an hour the next morning to level things out. We had some steep areas below the cabin that were difficult to mow, so he used the extra dirt to soften them. It really came out nice.

By the end of the day, we had a wall!

The next day, they assembled the opposite wall in two sections. Here is a video of one of those going up. They use an electric wall jack to raise it. You can also see these clamp-on forks on my tractor bucket.

They had me push the button on the second half, as Ryan had to be by the wall joint to finesse the two together. That was fun!

Once they completed that, they framed an end wall until the end of the day and called it a week. They will be back on Tuesday.

Even the beams for our covered entry are in place! They can be seen extending out from the wall on the left side of the photo.

This morning, we had to go to Lowe’s to pick up our flooring. As we were getting in the truck, we heard a roar through the trees:

A hot air balloon! Looks like our cabin isn’t the only thing going up in Leelanau County. 😊

That’s our update for now. Stay tuned to see how much the framers get done next week. Until then, safe and happy travels to all!

May 13, 2021 – Leelanau County, Michigan – Written by Jim.

When we last wrote, we had hopes of exploring a few new spots to us on our way back to Michigan. The weather had other plans, as we had a large snowstorm headed in from the west that threatened to block our path. We picked up the pace and left the southern Michigan storm in our rear view mirrors.

Once we were on our property, we hit the ground running. Our goal this summer is to get as much done as we can on our new cabin! We have been in touch with our subcontractors all winter, and it wasn’t long before Vince and his crew from Peninsula Excavating broke ground.

This is the last photo taken before that took place, about 5 minutes before he showed up. When he walked what we had staked out, he was concerned that the slope on the east side was a bit too close for the walkway we had planned on that side of the house. While he and I were scratching our heads, Diana headed to the other side of the house and eyed the copse of trees that was mostly leaning toward the building site. We quickly decided to get rid of them. Vince pushed one over with his loader and left the rest of them for us to deal with. That allowed us to move the house west 3 feet.

Within a few hours, we had ourselves a big sandbox! Most of it was a sand and gravel mixture with a couple pockets of football-sized glacial rocks.

We even found a large Charlevoix stone! This is actually coral from when Michigan was covered by a shallow sea. This rock is between 250 million and 450 million years old! We think it deserves a place of prominence in our cabin.

Once Vince headed out, we started cutting those trees. There were 11 of them of various sizes, and my intention was to fell them onto the driveway.

Since they were leaning away from the driveway and the wind was blowing from the wrong direction, 10 of the 11 ended up in what will be our bedroom! As the tallest of them was a diseased ash tree, it was a wise move to get rid of them.

Next up was our mason, Jim Ricketts. Here he has our footings formed up and ready. The inspector came first of the following week and approved the open footings, so we were ready for concrete…

…which is now complete. The next step will be for Jim to lay 7 course of block on top of these footings, which we are hoping will take place early next week.

The other thing we’ve been doing is bringing in our materials.

With the price of lumber being so high, we debated painting BRINKS on the sides of our truck! There were several loads like this. We did have the doors and windows delivered, along with the floor I-joists and framing lumber.

It sure is handy having forks for the bucket of our tractor! Those I-joists are 34 feet long and fill our barn from back to front. They just clear the overhead door’s safety beam.

The best story of the start of our build was when we received a call that our cabinets were being delivered. They weren’t supposed to come for another month, so we had to scramble. With the way the supply chain is so hit and miss, we felt it was wise to get them ASAP. They are RTA (ready to assemble) from Lily Ann Cabinets, in Adrian, Michigan. They actually had a showroom in Clearwater, Florida that we visited this past winter. When the rep from the trucking company called, he thought we could easily transfer them from their truck to our trailer. (The trucking company typically delivers curbside, as they are full sized semis). When the actual driver called, he was a bit worried about that idea. Doing that at the end of our driveway was not an option, as our road is on a hill. So we looked for a parking lot. We ended up at Leelanau Fruit Company, a local fruit processing plant. A gentleman walked out with a puzzled look on his face and I explained what we were needing to do and asked permission to use his parking lot. Just then, the truck driver pulled in. The man then ended up talking to the driver, and it was decided between the two of them that he would instead unload them at the dock with a forklift. Once that was completed, he used the forklift to put them on my trailer. These were three pallets of heavy cabinets!

How cool is that? And who was that man? None other than Glenn LaCross, President of Leelanau Fruit Company. Another gentleman who worked there also helped out, and he just happens to live just around the corner from us. Both men have family ties that date back to the mid 1800’s in Leelanau county. We offered to pay him for his time and efforts, but he refused. We made it a point to purchase some products in their online store instead. If you are in the mood for some delicious dark chocolate covered cherries, check out Leelanau Fruit’s website here. They are pretty darned good!

And last but not least, we received our trusses! You may recall last year when we built the barn, the driver wouldn’t attempt to come up our driveway, so she slid them off by the side of the road. We brought them up one at a time with our tractor, as shown in the photo below.

Those were 30 feet long. Well this year, our scissor trusses are a full seven feet longer! Kudos to Barb, the driver from this year, for walking the driveway with me. She really wanted to attempt getting them up the hill with her semi, but she realized she couldn’t make it when she saw the curves in our drive. So, we rigged up the tractor and went at it. Here is a little video of how we started out:

The little John Deere that could! The process of standing the trusses up onto the tractor was everything the two of us could handle (and a tad dangerous), so we came up with Plan B.

I built a 2×4 rack and screwed it to the front of our trailer. That made it so the trusses could clear the back of my truck. Definitely much easier and safer!

I was able to drag them on and off quite easily.

Hopefully we will be able to show some cement block and lumber going up in our next post, so be sure to stay tuned for that! Until then, safe and happy travels to all!